Quote
"[H]igher water content causes mixture too thin to accommodate bubbles... causing bubbles separating from the mixture..."
F
Foam concreteBasalt fibre is cut from a continuous basalt fibre with a diameter of — Foam concrete
"Basalt fibre is cut from a continuous basalt fibre with a diameter of 17 μm, 2.5 times superior in tensile strength to superior steel. Average fibre length: 6 to 24 mm. Recommendations for the dosage of basalt fibre: 1 kilogram per 1 cubic meter of mortar or concrete. It is necessary to introduce it into the mix with water, after stirring the fibre until it is evenly distributed in the water, it is necessary to slightly increase the mixing time (up to 5–10 min) for uniform distribution in volume."
F
Foam concrete
Foam concrete
author176 quotes
Foam concrete, also known as lightweight cellular concrete (LCC) and low density cellular concrete (LDCC), and by other names, is defined as a cement-based slurry, with a minimum of 20% foam entrained into the plastic mortar. As mostly no coarse aggregate is used for production of foam concrete the correct term would be called mortar instead of concrete; it may be called "foamed cement" as well. T
More by Foam concrete
View all →Quote
"Typically, the samples from the lowest part of the column were 16 to 32 kg/m3 (1 to 2 lb/ft3) denser than the samples from the top of the column. In extreme cases, variations as high as 320 kg/m3 (20 lb/ft3) were noted. Denser samples are stronger. In these low-density concretes, a 16- to 32-kg/m3 (1- to 2-lb/ft3) density difference can increase the unconfined compressive strength by 100 kPa (14.5 psi) or more."
F
Foam concreteQuote
"Practically, a sufficient flow range in a premixed paste is a proof of the effective production of FC. When the value of flow seen was lesser than the limit, the mixes of the developed premixed paste and foam was considered in-cohesive. The binders seemed to be covered by air bubbles, which collapsed afterwards. [W]hen the value of flow was greater than the limit, seclusion happened and foam bubbles inclined to collapse."
F
Foam concreteQuote
"The fibre matrix interface and matrix densification can deliver a greater load carrying capacity of FC reliant on the toughness of the fibres. The FRFC prolongs post-crack ductility even... [with] repeating loading cycles."
F
Foam concreteQuote
"The present paper attempts to develop structural fibered foamed concrete (SFFC) with 10–70 MPa [1,500-7,300 psi] compressive strength and 1000–1900 kg/m³ [62-119 lb/ft³] density."
F
Foam concreteQuote
"[F]oamed concrete has the potential to become a mainstream material that uses waste material successfully as a replacement for cement or fine aggregate..."
F
Foam concrete